Skip to main content
  • Original article
  • Open access
  • Published:

Effect of the salts of deep ocean water on the production of cordycepin and adenosine of Cordyceps militaris-fermented product

Abstract

Cordyceps militaris is a type of entomogenous fungi and has been widely used as a medicinal fungus in Asia. Cordycepin produced by C. militaris has also been found to protect the liver. Moreover, deep ocean water (DOW) was proven to increase the functional compounds of functional fungi-fermented products. However, the regulation of the metals in DOW is still unclear. Therefore, this study investigated the effect of DOW and certain major ions on the production of cordycepin and adenosine of C. militaris. The results indicated that, compared with using ultra-pure water (UPW), using DOW to cultivate C. militaris in a submerged culture increases the production of biomass and adenosine (p < 0.05). In the results of solid culture, the concentration of DOW exhibits a dose effect on cordycepin production. DOW contains ions that can improve the effectiveness of cordycepin, such as Mg2+, Na+, Ca2+, Fe2+, and NO3 , whereas the ion Cl features an inhibitory effect. Moreover, Mg2+, Na+, K+, Ca2+, Fe2+, and SO4 2−can increase the production of adenosine, whereas Cl cannot. However, the synthetic water made from various types of sodium salts (MgCl2, NaCl, KCl, CaCl2, FeCl2) had nearly the same effect on cordycepin production as that of DOW.

Introduction

Deep ocean water (DOW) is characterized by low temperature, cleanness, and affluent production of inorganic nutrients and minerals. In recent years, because of its medicinal value, DOW has been extensively studied. Previous studies have noted that DOW has several health benefits, such as mitigating skin inflammation (Hataguchi et al. 2005), lowering blood lipids (Miyamura et al. 2004), reducing blood sugar (Hwang et al. 2009a), and reducing obesity (Hwang et al. 2009b). Moreover, DOW can be used to increase production of functional ingredients of microorganisms (Lee 2015). Studies have found that DOW can increase the functional ingredient production of monascin and ankaflavin of red mold dioscorea as well as triterpenoids, polysaccharide, and flavonoids of Antrodia camphorata (Lee et al. 2011; Wang et al. 2013a). Red mold dioscorea cultured by DOW lowers blood lipids and obesity more than that cultured by reverse osmosis water (ROW) and ultra-pure water (UPW) (Lee et al. 2011; Wang et al. 2013b). Moreover, compared with A. camphorata cultured by ROW, A. camphorata cultured by DOW protects the liver more effectively (Wang et al. 2013a). However, functional ions and the effects of ions in DOW on the growth and metabolites production of the functional fungi are still unclear incurrent. It should be an important topic for the application of DOW in future.

Recently, Cordyceps militaris has been regarded as an alternative to Ophiocordyceps sinensis. C. militaris has a similar functional composition to that of O. sinensis (Wang and Yao 2011). C. militaris also has antioxidant (Yu et al. 2006), antiinflammatory (Won and Park 2005), and antitumor effects (Yoo et al. 2004) as well as enhances sexual performance (Chang et al. 2008). According to relevant studies, the activity levels of the essential amino acids, cordycepin, Cordyceps polysaccharide, and superoxide dismutase of artificially cultured C. militaris are all higher than those of wild O. sinensis (Dong et al. 2012).

This study used C. militaris BCRC 32219 as the testing strain and focused on solid culture to examine how various culture mediums and concentrations of DOW affect the production of adenosine and cordycepin of C. militaris. This study also analyzed the effect of the major ions in DOW on the production of adenosine and cordycepin of C. militaris by adding only one single type of salt.

Materials and methods

Chemicals

Yeast mold (YM) agar and broth were purchased from Difco Laboratories Co. (Detroit, MI, USA). Magnesium, sodium, potassium, calcium, zinc and iron standard solutions were purchased from Showa Chemical Co. (Tokyo, Japan). Ethanol (95 %) was purchased from Taiwan Tobacco and Liquor Co. (Taipei, Taiwan). The other chemicals purchased from Sigma Chemical Co. (St. Louis, MO, USA).

The preparation of DOW, SW, and various salts water

The concentrated DOW purchased from the Taiwan Yes Deep Ocean Water Co. (Hualien, Taiwan) was pumped from a depth of 670 m in the Pacific Ocean near the Eastern Taiwan and processed though the electrodeionization. According to our previous study, DOW including 20.65 mg/L Mg2+ was defined as onefold DSW (Wang et al. 2013a). In this study, 30-fold DOW (including 619.5 mg/L Mg2+) was prepared by the dilution of concentrated DOW (including 43,400 mg/L Mg2+) with UPW. The concentrations of the trace elements and minerals in 30X DOW included 619.5 mg/L Mg2+, 327 mg/L Na+, 132 mg/L K+, 5.13 mg/L Ca2+, 8.55 µg/L Fe2+, 1.156 mg/L nitrate, 649 mg/L sulfate, and 1.898 g/L chloride.

In the preparation of the various metals salts solution, Mg(NO3)2, NaCl, KCl, CaCO3, and (NH4)2Fe(SO4)2 solution were prepared according to the equal Mg2+, Na+, K+, Ca2+, Fe2+ concentrations in 10X-DOW, respectively. The five salts solutions were further mixed for the preparation of the synthetic water of mixed salts (Salt-SW). In the preparation of the sodium salts solution, NaNO3, Na2SO4, Na3PO4 and NaCl solutions were prepared according to equal SO4 2−, PO4 3−, NO3 , and Cl concentration in 30X or 60X DOW, respectively. These four sodium salts solutions were mixed for the preparation of a synthetic water of mixed sodium salts (Na-SW). In the preparation of the nitrate salts solution Mg(NO3)2, NaNO3, KNO3, Ca(NO3)2, Fe(NO3)2·6H2O solutions were prepared according to equal Mg2+, Na+, K+, Ca2+, and Fe2+ concentrations in 30X DOW, respectively. In the preparation of the chloride salts solutions, MgCl2, NaCl, KCl, CaCl2, FeCl2 solutions were prepared according to equal Mg2+, Na+, K+, Ca2+, and Fe2+ concentrations in 30X DOW, respectively. These five chloride salts solutions were further mixed for the preparation of a synthetic water of mixed chloride salts (Cl-SW).

Microorganism and seed cultures

C. militaris BCRC 32219 was purchased from the Bioresource Collection and Research Center (Hsinchu, Taiwan). C. militaris was maintained on YM agar at 24 °C and transferred to fresh medium for 10 days intervals. Seed cultures were prepared by transferring a loopful of colony from YM agar slant into a 500-mL Hinton flask containing 100 mL medium (3 g/L yeast extract, 5 g/L malt extract, 10 g/L peptone, 3 g/L dextrose). The cultures were incubated at 28 °C and 100 rpm for 5 days. After that, inoculum sizes 5 % was transferred to submerged or solid cultured substrate.

Submerged fermentation of C. militaris in DOW or UPW

Submerged fermentation was carried out using a 500-mL Hinton flask containing 100-mL medium (3 g/L yeast extract, 5 g/L malt extract, 10 g/L peptone, 3 g/L dextrose in UPW or DOW). The cultures were incubated at 28 °C for 5 days at 100 rpm. After submerged culture, mycelium and filtrate were separated using filter paper. The mycelium was dried by freeze dryer and then weighted. The dried mycelium powder and fresh filtrate was analyzed for intracellular and extracellular β-1,3 glucan, respectively.

Solid fermentation of C. militaris in DOW or ROW

Thirty grams oat substrates was soaked in 30 mL UPW, DOW, SW, or various salts water, and then was autoclaved for 20 min at 121 °C in a 500-mL glass bottle. After being cooled, the substrate was inoculated with a 10 % (v/w) seed culture medium. The inoculated substrate was cultured at 24 °C for 20 days in a dark incubator. After dark culture, C. militaris was then cultured at 14 °C under a 12 h light:12 h dark cycle (light on at 6:00) for 60 days. After fermentation, the crushed and dried product was used for the experiments.

Determination of β-1,3 glucan

The selective aniline blue reaction was employed to detect the existence of β-1,3 glucan. The method described by the previous studies (Wood and Fulcher 1984; Young and Jacobs 1998) were followed with some modifications. The sample was dissolve with 0.3 N NaOH and stirred at ambient temperature for completely dissolve. The pH of the sample solution was then adjusted to 11.5 ± 0.1 by adding 1 N HCl and the volume was made to 10 mL using Na2HPO4–NaOH buffer (pH 11.5 containing 0.5 M NaCl). A 0.2 mL of sample was reacted with 0.1 mL aniline blue (1 mg/mL) for 2 h at ambient temperature. The excitation and emission wavelength were set at 395 and 495 nm, respectively.

Determination of cordycepin and adenosine

The powder of C. militaris-fermented product (0.1 g) was extracted respectively with 1 mL of methanol at 50 °C for 1 h. The extracts (10 %, w/v) were further filtered with 0.45 μm pore size filter and analyzed by HPLC (Model L-2130, Hitachi Co., Tokyo, Japan) on a C18 column (25 cm × 4.6 mm i.d., 5 μm, Luna®, Phenomenex, Torrance, CA, USA) using the gradient elution. HPLC was performed according to the method described previously (Yu et al. 2007) in triplicate. Cordycepin and adenosine were separated by gradient elution using the mobile phase with the composition of water–methanol (95.0/5.0 to 58.4/41.6 in 20 min, v/v). The flow rate was set at 0.8 mL/min. Cordycepin and adenosine were detected using a photodiode array detector (Model L-2455 DAD, Hitachi Co.) set at 260 nm and full wavelength.

Statistical analysis

Data are expressed as mean ± standard deviation. Analysis of variance by Duncan’s test and Pearson’s product-moment correlation coefficient test were determined using SPSS version 10.0 software (SPSS Institute, Inc., Chicago, IL, USA). Differences with p < 0.05 were considered statistically significant.

Results

Effect of deep ocean water on the production of mycelium and certain functional ingredients under submerged culture

This study investigated the effect of DOW on the production of C. militaris mycelium and certain functional ingredients of C. militaris under submerged culture. As presented in Table 1, compared with ultra-pure water (UPW), DOW enhanced the production of C. militaris mycelium by 23 % (p < 0.05), which significantly increased the production of adenosine by 18 % (p < 0.05). However, DOW did not significantly affect the production of intracellular and extracellular β-1,3-glucan (p > 0.05). Moreover, under the submerged culture, the experimental results of this study revealed that no cordycepin was produced in the fermentative liquid and mycelium of UPW and DOW.

Table 1 Effect of DOW on the biomass, cordycepin, adenosine, intracellular β-1,3-glucan, and extracellular β-1,3-glucan production of C. militaris in submerged culture

Effect of various deep ocean water concentrations on production of cordycepin and adenosine in Cordyceps militaris-fermented products

Cordycepin cannot be produced by cultivating C. militaris in submerged culture. Therefore, this study focused on solid culture and explored the effect of various factors on production of the functional ingredients of C. militaris. For this phase, the DOW of various concentrations was used as the water source for C. militaris-fermented production. The effect of DOW on the production of adenosine and cordycepin was also analyzed. Figure 1a shows that after 60 days’ fermentation, the C. militaris-fermented products with UPW, 10X-DOW, or 20X-DOW sources had increased cordycepin production; however, the increase was lower than that of the C. militaris-fermented products with the 30X-DOW source. When the fermentation was extended to 80 days, the C. militaris-fermented product with the 30X-DOW source had the highest cordycepin production. This cordycepin production was higher than that of the 20X-DOW, 10X-DOW, and UPW sources by 22 % (p < 0.01), 26 % (p < 0.01), and 64 % (p < 0.01), respectively, displaying a dose effect.

Fig. 1
figure 1

 Effect of various concentration of DOW on the cordycepin (a) and adenosine (b) production of C. militaris-fermented oats in solid culture. Data are presented as mean ± SD (n = 3). ** indicated the significant difference (p < 0.01) as compared with UPW.

Figure 1b presents the production state of adenosine. When DOW of various concentrations was used as the water source for C. militaris-fermented production, the production of adenosine at various time points did not differ significantly (p > 0.05).

Effect of the major metal ions of deep ocean water on production of cordycepin and adenosine of Cordyceps militaris-fermented products

DOW is rich in the concentration of Mg2+, Na+, K+, Ca2+, Zn2+, and Fe2+, which is possible to enhance the production of the functional metabolites. Therefore, the effect of the major metal ions in DOW on the production of cordycepin and adenosine were further analyzed in this study. Figure 2a shows the effect of DOW, Salt-SW, and various salts solution on cordycepin production. The concentration of Mg2+, Na+, K+, Ca2+, Fe2+ in Mg(NO3)2, NaCl, KCl, CaCO3, and (NH4)2Fe(SO4)2 were equal to that in 10X-DOW, respectively. The five salts solutions were mixed for the preparation of 10X-Salt-SW. As shown, 10X-DOW, 10X-Salt-SW, and Mg(NO3)2 solution promoted the production of cordycepin (p < 0.05). However, compared with the production of cordycepin in the UPW group, the NaCl solution reduced the production of cordycepin by 57 % and had a suppressive effect (p < 0.001). The effect of KCl, CaCO3, and (NH4)2Fe(SO4)2 solutions were not significant (p > 0.05). Moreover, the effects of DOW, Salt-SW, and various salts solution on the production of adenosine are presented in Fig. 2b. 10X-DOW and 10X-Salt-SW enhanced the production of adenosine (p < 0.05). Among the salts solution, only (NH4)2Fe(SO4)2 solutions promoted the production of adenosine (p < 0.05).

Fig. 2
figure 2

Effect of major metal ions in DOW on the cordycepin (a) and adenosine (b) production of C. militaris-fermented oats in solid culture. The concentration of Mg2+, Na+, K+, Ca2+, Fe2+ in Mg(NO3)2, NaCl, KCl, CaCO3, and (NH4)2Fe(SO4)2 were equal to that in 10X-DOW, respectively. Salt-SW was a mixture of the five salt solutions. Data are presented as mean ± SD (n = 3). *, *** indicated the significant difference (p < 0.05, p < 0.001, respectively) as compared with UPW.

Effect of various sodium salts on production of cordycepin and adenosine of Cordyceps militaris-fermented products

According to above results (Fig. 2a), NaCl solution significantly suppressed the production of cordycepin. This section further discusses the effect of various sodium salts on production of cordycepin and adenosine. According to the comparison in Fig. 3, at the 30-fold sodium salt concentration, DOW, Na-SW, NaNO3, Na2SO4, Na3PO4, and NaCl, the C. militaris-fermented products with the DOW source and NaNO3 respectively had 52 and 46 % higher cordycepin production than the C. militaris-fermented products with UPW (p < 0.01). However, after fermentation, NaCl increased cordycepin production by 58 % (p < 0.001). Moreover, DOW, Na-SW, and NaNO3 enhanced adenosine production by 60, 74, and 104 % (p < 0.05), respectively. Nevertheless, the selection of DOW, Na2SO4, Na3PO4, and NaCl did not affect the production of adenosine. At a concentration of 60-fold, the DOW, Na-SW, NaNO3, Na2SO4, and Na3PO4 groups exhibited a decline in cordycepin production. However, in contrast to the UPW group, the NaCl group showed a significant 70 % decrease in the production of cordycepin (p < 0.001). Furthermore, DOW and Na2SO4 increased adenosine production (p < 0.05), whereas adenosine production decreased in the other groups.

Fig. 3
figure 3

Effect of various sodium salt ions on the cordycepin and adenosine production of C. militaris-fermented oats in solid culture. DOW (a), Na-SW (b), NaNO3 (c), Na2SO4 (d), Na3PO4 (e), or NaCl (f) solution was added to the solid substrate of C. militaris during solid culture, respectively. NaNO3, Na2SO4, Na3PO4 and NaCl solution included equal SO4 2−, PO4 3−, NO3 , and Cl concentration to that in 30X or 60X DOW, respectively. Na-SW was a mixture of the four sodium salt solutions. Data are presented as mean ± SD (n = 3). *, **, *** indicated the significant difference (p < 0.05, p < 0.01, p < 0.001, respectively) as compared with UPW.

Effect of various nitrate salts on production of cordycepin and adenosine in Cordyceps militaris-fermented products

As shown in Fig. 3, at the 30-fold sodium salt concentration, only NaNO3 could enhance cordycepin and adenosine production. Therefore, this section focuses on the concentration of NaNO3 and discusses the effect of various combinations of nitrate salts on the production of cordycepin and adenosine. The 30X concentration of Mg2+, Na+, K+, Ca2+, Fe2+ in Mg(NO3)2, NaNO3, KNO3, Ca(NO3)2, Fe(NO3)2·6H2O were equal to that in 30X-DOW. According to Fig. 4a, DOW, Mg(NO3)2, NaNO3, Ca(NO3)2, and Fe(NO3)2 had significantly increased cordycepin production (p < 0.01). However, KNO3 did not exhibit such an increase (p < 0.05). Moreover, Fig. 4b illustrates that Mg(NO3)2, NaNO3, KNO3, Ca(NO3)2, and Fe(NO3)2 significantly increased adenosine production (p < 0.001), whereas 30X-DOW moderately increased adenosine production (p < 0.05).

Fig. 4
figure 4

Effect of various nitrate salts on the cordycepin (a) and adenosine (b) production of C. militaris-fermented oats in solid culture. The 30X concentration of Mg2+, Na+, K+, Ca2+, Fe2+ in Mg(NO3)2, NaNO3, KNO3, Ca(NO3)2, Fe(NO3)2·6H2O were equal to that in 30X-DOW. Data are presented as mean ± SD (n = 3). *, **, *** indicated the significant difference (p < 0.05, p < 0.01, p < 0.001, respectively) as compared with UPW.

Effect of various chloride salts on production of cordycepin and adenosine in Cordyceps militaris-fermented products

Figure 4 illustrates that at the 30-fold sodium salt concentration, NaNO3 enhanced cordycepin production, but Na2SO4 and NaPO4 did not enhance cordycepin production. However, NaCl significantly reduced cordycepin production (p < 0.001). Therefore, this section uses solutions with equal metal ion concentrations to that in 30X-DOW to discuss the effect of various chloride salts on production of cordycepin and adenosine. As shown in Fig. 5a, MgCl2, NaCl, and KCl significantly reduced cordycepin production (p < 0.05), and cordycepin production in the CaCl2 and FeCl2 solutions declined. The Cl-SW solution produced by combining all five chloride salts significantly reduced cordycepin production (p < 0.05).

Fig. 5
figure 5

Effect of various chloride salts on the cordycepin (a) and adenosine (b) production of C. militaris-fermented product in solid culture. The 30X concentration of Mg2+, Na+, K+, Ca2+, Fe2+ in MgCl2, NaCl, KCl, CaCl2, FeCl2 were equal to that in 30X-DOW. Cl-SW was a mixture of the five chloride salt solutions. Data are presented as mean ± SD (n = 3). *, **, *** indicated the significant difference (p < 0.05, p < 0.01, p < 0.001, respectively) as compared with UPW.

The adenosine production results are shown in Fig. 5b. DOW and Cl-SW enhanced the production of adenosine (p < 0.05). Furthermore, MgCl2, NaCl, KCl, and FeCl2 significantly enhanced the production of adenosine (p < 0.05), whereas CaCl2 had no significant effect on adenosine production (p < 0.05). However, Cl-SW enhanced adenosine production (p < 0.05).

Discussion

As confirmed in previous studies, DOW can enhance production of the functional ingredients of red mold dioscorea such as monascin and ankaflavin as well as reduce the production of hepatotoxin, nephrotoxin, and citrinin (Lee et al. 2011). DOW can also promote production of A. camphorata mycelium as well as increase production of the functional ingredients of triterpenoids, polysaccharide, and flavonoids (Wang et al. 2013a). This study focuses on submerged culture to investigate the effect of DOW on production of C. militaris mycelium and the functional ingredients of C. militaris. Table 1 demonstrates that DOW promoted the production of C. militaris mycelium more than UPW did and significantly increased the production of adenosine (p < 0.05). This result agrees with those of previous studies except for DOW significantly affecting the production of intracellular and extracellular β-1,3-glucan (p < 0.05), a phenomenon that was not observed in this study.

Moreover, this study addressed the effect of DOW of various concentrations on the production of cordycepin and adenosine in C. militaris-fermented products. In this study, cordycepin production increased as the concentration of DOW increased. The content of cordycepin in the 30X-DOW solution reached the highest point on the 80th day of fermentation (p < 0.01). The DOW of various concentrations did not significantly enhance the production of adenosine (p > 0.05). The results were compared with the SW results. Mg(NO3)2 promoted cordycepin production (p < 0.05), NaCl significantly suppressed cordycepin production (p < 0.001), and KCl reduced cordycepin production. However, NaCl and KCl had Cl, whereas CaCO3 and (NH4)2Fe(SO4)2 had no significant effect on cordycepin production (p > 0.05). Furthermore, SW can increase cordycepin production to a degree similar to that of DOW. (NH4)2Fe(SO4)2 increases adenosine production (p < 0.05). However, the other four salt solution did not have this effect (p > 0.05). SW can also increase adenosine production to a degree similar to that of DOW.

The results illustrated that all the metal ions in DOW can either increase or not affect cordycepin production. However, the production of cordycepin in NaCl solution significantly decreases after fermentation. Na+ constitutes a large proportion of DOW. This study compared the effects of DOW and various sodium salt solutions with concentrations equal to that of DOW on the production of cordycepin and adenosine. At the 30-fold sodium salt concentration, NO3 increased the production of cordycepin (p < 0.01) and adenosine (p < 0.05) the most; however, it had no effect on adenosine production. SO4 2− and PO4 had no effect on the production of cordycepin and adenosine. SW did not significantly increase cordycepin production but significantly increased the production of adenosine (p < 0.05). At the 60-fold sodium salt concentration, the production of cordycepin and adenosine with SW, NO3 , and PO4 decreased. At this concentration, the cordycepin production with SO4 2− declined as well, but the adenosine production increased significantly (p < 0.05). Concurrently, Cl- of the 60-fold concentration significantly reduced cordycepin production (p < 0.001). The NO3 , SO4 2−, PO4 , and Cl used in this study refer to sodium salts. The NaCl solution reduced cordycepin production, whereas the NaNO3 solution increased cordycepin production. Therefore, we conclude that NO3 can increase cordycepin production, that Cl may reduce cordycepin production, and that NaCl solution has no effect on adenosine production. Nevertheless, the NaNO3 solution promoted adenosine production. At the 60-fold sodium salt concentration, only the Na2SO4 solution enhanced adenosine production. Therefore, NO3 and SO4 2− may enhance adenosine production, whereas Cl does not affect adenosine production.

Regarding to the effect of nitrates of various compositions on the production of cordycepin and adenosine (Fig. 4), Mg(NO3)2, NaNO3, Ca(NO3)2, and Fe(NO3)2 significantly increased cordycepin production (p < 0.01). However, NaNO3 did not have this effect (p > 0.05). Mg(NO3)2, NaNO3, KCl, Ca(NO3)2, and Fe(NO3)2 significantly increases adenosine production (p < 0.001). Because equal amounts of NO3 produces equal effects, Mg2+, Na+, Ca2+, and Fe2+ are estimated to be primarily responsible for increasing production of cordycepin and adenosine. In addition, K+ is likely to significantly increase adenosine production.

According to Fig. 5, Cl can suppress cordycepin production. This study used various chloride salts to investigate the effect of metal ions on the production of cordycepin and adenosine. All the chloride salts, MgCl2, NaCl, and KCl significantly reduced cordycepin production (p < 0.05). Furthermore, CaCl2 and FeCl2 reduced cordycepin production. Therefore, the SW composed of the five chloride salts significantly reduced cordycepin production (p < 0.05). Furthermore, MgCl2, NaCl, KCl, and FeCl2 significantly increased adenosine production (p < 0.05). However, CaCl2 did not increase adenosine production (p > 0.05). SW increased adenosine production (p < 0.05). The addition of Mg(NO3)2, NaNO3, KNO3, Ca(NO3)2, or Fe(NO3)2 can significantly enhance cordycepin production. However, in all the chloride salts, MgCl2, NaCl, KCl, CaCl2, and FeCl2 either significantly reduced cordycepin production or caused a declining trend in cordycepin production. Therefore, Cl might contribute to reducing cordycepin production in C. militaris-fermented products.

The effect of SW on the production of cordycepin and adenosine varied depending on the combination of sodium salts. As shown in Fig. 3, Na-SW composed of various sodium salts had no significant effect on cordycepin production but enhanced adenosine production. The increase of cordycepin production might have been attributed to NaNO3. Moreover, NaCl suppressed the production of cordycepin, and the effect of Na2SO4 and NaPO4 on cordycepin production was not significant. Therefore, the combined effect of the four sodium salts rendered the resultant Na-SW least effective for promoting cordycepin production. Moreover, NaNO3 enhanced adenosine production, whereas Na2SO4, NaPO4, and NaCl had no effect on adenosine production. Hence, the combination of these four sodium salts resulted in the Na-SW that significantly promoted adenosine production. Figure 5a, b show that the Cl-SW of various combinations of chloride salts suppressed cordycepin production and promoted adenosine production. This Cl-SW effect might have occurred because MgCl2, NaCl, and KCl were all active in suppressing cordycepin production, and CaCl2 and FeCl2 were not significantly associated with cordycepin production. Therefore, the Cl-SW comprising the five chloride salts reduced cordycepin production. Moreover, except for CaCl2, the other chloride salts increased adenosine production. Therefore, the Cl-SW increased adenosine production. As confirmed in Figs. 2 and 5 demonstrate that Salt-SW increased the production of cordycepin and adenosine, and the Mg(NO3)2 sodium salt should be the functional salt for increasing the production of cordycepin and adenosine. The results of fermentation in various chloride salt mediums revealed that NaCl and KCl suppressed cordycepin production but enhanced adenosine production. This result is verified in Fig. 5a, b. However, CaCO3 and (NH4)2Fe(SO4)2 least enhanced cordycepin production, whereas (NH4)2Fe(SO4)2 increased adenosine production (Fig. 2). Figure 4a, b imply that Ca2+ and Fe2+ are likely to enhance the production of cordycepin and adenosine. Hence, the Salt-SW comprising Mg(NO3)2, NaCl, KCl, CaCO3, and (NH4)2Fe(SO4)2 enhanced production of cordycepin and adenosine. Furthermore, Salt-SW produced by combining sodium and chloride salts increased adenosine production to the same extent that DOW did. However, the Na-SW comprising only sodium salts increased cordycepin production to nearly the same extent that DOW did.

The study by Cui and Zhang (2012) noted that the addition of Mg2+ and Mn2+ in the cultivation of C. militaris in submerged culture significantly promoted C. militaris mycelium and extracellular polysaccharide production. Moreover, adding sodium selenite into the solid culture mediums for C. militaris cultivation significantly increased the production of cordycepin, cordyceps acid, cordyceps polysaccharide, and organic selenium of the C. militaris fruit body compared with the control group that had no sodium selenite. This production increase was proportional to the concentration of sodium selenite (Dong et al. 2012). The addition of 10 mM Ca2+ in Ganoderma liquid culture mediums can significantly increase the production of Ganoderma acid (Xu and Zhong 2012). In summary, compared with UPW, DOW can more effectively promote the growth of C. militaris mycelium and enhance the production of cordycepin, its functional ingredient. Moreover, the concentration of DOW has a dose effect on cordycepin production. The enhancing effect of DOW on cordycepin production is mainly attributed to its ions such as Mg2+, Na+, Ca2+, Fe2+, and NO3 . However, the Cl in DOW suppresses cordycepin production. For adenosine, Mg2+, Na+, K+, Ca2+, Fe2+ and SO4 2− have the ability of increasing its production, but such an ability is not observed for Cl. Furthermore, the DOW ions can increase cordycepin production. This ability might be induced by the pressure of the C. militaris growth environment, which forces C. militaris to enter the secondary metabolic phase and begin producing secondary metabolites. This ability could stem from ions in DOW that serve as enzyme or protein cofactors in cultivating C. militaris and produce cordycepin to promote the growth of mycelium and production of the functional ingredients of C. militaris. The effect of Na-SW on the production of cordycepin and adenosine varies depending on the combination of sodium salts. Therefore, the production of cordycepin can be increased by adding nitrates and reducing the production of Cl in DOW. Moreover, chloride salts, nitrates, and SO4 2− can be added to DOW to increase adenosine production.

This study employed DOW to cultivate C. militaris in submerged and solid culture and investigated the effect of DOW on the production of C. militaris’ fermentative products, namely cordycepin and adenosine. The results demonstrated that using 30X-DOW as a water source to produce C. militaris-fermented products can significantly increase the production of cordycepin. This cordycepin production is 65 % higher than the C. militaris-fermented products of the UPW water solution (p < 0.001). The concentration of DOW also has a dose effect on cordycepin production. Moreover, the Mg2+, Na+, Ca2+, Fe2+, and NO3 in DOW increase cordycepin production; however, the Cl in DOW exhibits an opposite effect. Mg2+, Na+, K+, Ca2+, Fe2+, and SO4 2− can increase adenosine production, but Cl cannot. The Cl-SW containing MgCl2, NaCl, KCl, CaCl2, FeCl2 can not only increase adenosine production but also promote cordycepin production to nearly the same extent that DOW does.

References

  • Chang Y, Jeng KC, Huang KF, Lee YC, Hou CW, Chen KH et al (2008) Effect of Cordyceps militaris supplementation on sperm production, sperm motility and hormones in Sprague–Dawley rats. Am J Chin Med 36:849–859. doi:10.1142/S0192415X08006296

    Article  CAS  PubMed  Google Scholar 

  • Cui JD, Zhang YN (2012) Evaluation of metal ions and surfactants effect on cell growth and exopolysaccharide production in two-stage submerged culture of Cordyceps militaris. Appl Biochem Biotechnol 168:1394–1404

    Article  CAS  PubMed  Google Scholar 

  • Dong JZ, Lei C, Ai XR, Wang Y (2012) Selenium enrichment on Cordyceps militaris link and analysis on its main active components. Appl Biochem Biotechnol 166:1215–1224. doi:10.1007/s12010-011-9506-6

    Article  CAS  PubMed  Google Scholar 

  • Hataguchi Y, Tai H, Nakajima H, Kimata H (2005) Drinking deep-sea water restores mineral imbalance in atopic eczema/dermatitis syndrome. Eur J Clin Nutr 59:1093–1096. doi:10.1038/sj.ejcn.1602218

    Article  CAS  PubMed  Google Scholar 

  • Hwang HS, Kim HA, Lee SH, Yun JW (2009a) Anti-obesity and antidiabetic effects of deep sea water on ob/ob mice. Mar Biotechnol (NY) 11:531–539. doi:10.1007/s10126-008-9171-0

    Article  CAS  Google Scholar 

  • Hwang HS, Kim SH, Yoo YG, Chu YS, Shon YH, Nam KS et al (2009b) Inhibitory effect of deep-sea water on differentiation of 3T3-L1 adipocytes. Mar Biotechnol (NY) 11:161–168. doi:10.1007/s10126-008-9131-8

    Article  CAS  Google Scholar 

  • Lee CL (2015) The advantages of deep ocean water for the development of functional fermentation food. Appl Microbiol Biotechnol 99:2523–2531. doi:10.1007/s00253-015-6430-7

    Article  CAS  PubMed  Google Scholar 

  • Lee CL, Kung YH, Wang JJ, Lung TY, Pan TM (2011) Enhanced hypolipidemic effect and safety of red mold dioscorea cultured in deep ocean water. J Agric Food Chem 59:8199–8207. doi:10.1021/jf201948v

    Article  CAS  PubMed  Google Scholar 

  • Miyamura M, Yoshioka S, Hamada A, Takuma D, Yokota J, Kusunose M et al (2004) Difference between deep seawater and surface seawater in the preventive effect of atherosclerosis. Biol Pharm Bull 27:1784–1787

    Article  CAS  PubMed  Google Scholar 

  • Wang XL, Yao YJ (2011) Host insect species of Ophiocordyceps sinensis: a review. Zookeys 127:43–59. doi:10.3897/zookeys.127.802

    Article  PubMed  Google Scholar 

  • Wang LC, Kuo IU, Tsai TY, Lee CL (2013a) Antrodia camphorata-fermented product cultured in deep ocean water has more liver protection against thioacetamide-induced fibrosis. Appl Microbiol Biotechnol 97:9955–9967. doi:10.1007/s00253-013-5214-1

    Article  CAS  PubMed  Google Scholar 

  • Wang LC, Lung TY, Kung YH, Wang JJ, Tsai TY, Wei BL et al (2013b) Enhanced anti-obesity activities of red mold dioscorea when fermented using deep ocean water as the culture water. Mar Drugs 11:3902–3925. doi:10.3390/md11103902

    Article  PubMed Central  PubMed  Google Scholar 

  • Won SY, Park EH (2005) Anti-inflammatory and related pharmacological activities of cultured mycelia and fruiting bodies of Cordyceps militaris. J Ethnopharmacol 96:555–561. doi:10.1016/j.jep.2004.10.009

    Article  PubMed  Google Scholar 

  • Wood PJ, Fulcher RG (1984) Specific interaction of aniline blue with (1 → 3)-β-d-glucan. Carbohydr Polym 4:49–72

    Article  CAS  Google Scholar 

  • Xu YN, Zhong JJ (2012) Impacts of calcium signal transduction on the fermentation production of antitumor ganoderic acids by medicinal mushroom Ganoderma lucidum. Biotechnol Adv 30:1301–1308. doi:10.1016/j.biotechadv.2011.10.001

    Article  CAS  PubMed  Google Scholar 

  • Yoo HS, Shin JW, Cho JH, Son CG, Lee YW, Park SY et al (2004) Effects of Cordyceps militaris extract on angiogenesis and tumor growth. Acta Pharmacol Sin 25:657–665

    CAS  PubMed  Google Scholar 

  • Young S, Jacobs RR (1998) Sodium hydroxide-induced conformational change in schizophyllan detected by the fluorescence dye, aniline blue. Carbohydr Res 310:91–99

    Article  CAS  Google Scholar 

  • Yu HM, Wang BS, Huang SC, Duh PD (2006) Comparison of protective effects between cultured Cordyceps militaris and natural Cordyceps sinensis against oxidative damage. J Agric Food Chem 54:3132–3138. doi:10.1021/jf053111w

    Article  CAS  PubMed  Google Scholar 

  • Yu R, Ye B, Yan C, Song L, Zhang Z, Yang W, Zhao Y (2007) Fingerprint analysis of fruiting bodies of cultured Cordyceps militaris by high-performance liquid chromatography-photodiode array detection. J Pharm Biomed Anal 44:818–823

    Article  CAS  PubMed  Google Scholar 

Download references

Acknowledgements

This study was supported by a grant from the National Science Council, R.O.C. (NSC 101-2313-B-143-003-MY3) and Ministry of Economic Affairs, R.O.C. (103-EC-17-A-32-S1-230).

Competing interests

The authors declare that they have no competing interests.

Ethical statement

This article does not contain any studies with human participants or animals performed by any of the authors.

Author information

Authors and Affiliations

Authors

Corresponding author

Correspondence to Chun-Lin Lee.

Rights and permissions

Open Access This article is distributed under the terms of the Creative Commons Attribution 4.0 International License (http://creativecommons.org/licenses/by/4.0/), which permits unrestricted use, distribution, and reproduction in any medium, provided you give appropriate credit to the original author(s) and the source, provide a link to the Creative Commons license, and indicate if changes were made.

Reprints and permissions

About this article

Check for updates. Verify currency and authenticity via CrossMark

Cite this article

Hung, YP., Wang, JJ., Wei, BL. et al. Effect of the salts of deep ocean water on the production of cordycepin and adenosine of Cordyceps militaris-fermented product. AMB Expr 5, 53 (2015). https://doi.org/10.1186/s13568-015-0140-5

Download citation

  • Received:

  • Accepted:

  • Published:

  • DOI: https://doi.org/10.1186/s13568-015-0140-5

Keywords